2004 CV Sport Air Suspension FAIL... - Ford Forums - Mustang Forum, Ford Trucks, Ford Focus and Ford Cars

Kleetus · 10-25-2010, 18:57

Hey gang... It's been a while since I've been on here, but that said... got an issue here.

2004 Crown Vic Sport, the air suspension just went paws up on me yesterday, and gave the the dash light. Suspension is bottomed out, but the pump won't come on.

Jacked her up, the little wiper arm on the axle is still attached so I was hoping that would cure it, but no... Checked the fuses, fine, checked the relay, fine, fiddled with the trunk switch, fine.

Can't locate the control module or the pump. I haven't ordered the service manuals for this one yet, frankly I forgot about it.

Any hints? I can't for the life of me figure why with no blown fuse why the pump wouldn't attempt to run, unless of course the module went out.

The only operational clue I can give is the last 2 weeks or so, the car seemed to be a bit low. Put a couple people in it, and it came up. It's actually my mother's car, and when she was coming home from work, everything was fine a mile or two into the drive then went around a corner and the car decided to sit down and the light came on. Not much to go on I know...

Thank for the assistance!

**Bert** · 10-25-2010, 19:40

How about fuse 114 under the hood and fuse 16 inside?

Kleetus · 10-25-2010, 21:29

Checked them too... reseated all the fuses, none blown there either.

One new piece of information. I now have the error code P1000... which I will now look up.

Kleetus · 10-26-2010, 20:47

Disaster averted/discovered... the air pump rotted into two pieces.

The housing that contains the pump itself split and jammed the motor.

All I have to do now is find a replacement that won't cost an arm and leg...

Thanks for the help guys!

**Bert** · 10-26-2010, 21:10

You might try here. Car-Part.com--Used Auto Parts Market