U.s.a.:mazda6 Gets Acceptable Rating In 5 Mph Crash Tests - Ford Forums - Mustang Forum, Ford Trucks, Ford Focus and Ford Cars
Ford Forum Ford Forum

» Auto Insurance
» Featured Product
» Wheel & Tire Center

Go Back   Ford Forums - Mustang Forum, Ford Trucks, Ford Focus and Ford Cars > Ford Cars and PAG Vehicles > Mazda Forum
Register Home Forum Active Topics Photo Gallery Auto Loans Garage Mark Forums Read Auto Escrow

Mazda Forum This area is for discussion of Mazda vehicles

FordForums.com is the premier Ford Forum on the internet. Registered Users do not see the above ads.
Reply
 
LinkBack Thread Tools Display Modes
Old 09-07-2003, 21:56   #1 (permalink)
Registered User
 
Stacy94PGT's Avatar
 
Join Date: Feb 2001
Location: The Hills of North Georgia,USA
Posts: 7,859
U.s.a.:mazda6 Gets Acceptable Rating In 5 Mph Crash Tests

Auto Channel
Insurance Institute for Highway Safety Bumper Test

ARLINGTON, VA -- Bumpers on the midsize 2003 Mazda6 performed reasonably well in 5 mph crash tests conducted recently by the Insurance Institute for Highway Safety, but results for five other vehicles were disappointing. The midsize 2003 Infiniti G35, the 2004 Nissan Quest minivan, and the large luxury 2003 Mercedes E class earned poor ratings for bumper performance. The midsize 2003 Saab 9-3 and the 2004 Toyota Sienna minivan were marginal. None earned a good rating.

The Quest sustained far more damage than its predecessor model, which the Institute tested in 1999, dropping from a rating of good to poor. The 9-3 and the Sienna also performed somewhat worse than earlier designs.

The vehicles were tested in four 5 mph impacts -- front- and rear-into-flat-barrier plus front-into-angle-barrier and rear-into-pole. The tests assess how well bumpers can prevent damage in low-speed impacts, which are common in commuter traffic and parking lots. Average damage per test ranged from about $340 for the Mazda6 to $1,480 for the worst performer, the Infiniti G35.

Three midsize cars: Among the midsize cars the Institute tested, only the Mazda6 is equipped with bumpers that do an acceptable job of protecting the vehicle from significant damage. In the front-into-flat-barrier test, damage was limited because the bumper is designed to absorb the energy of a minor impact and keep it away from the car body.

"Mazda engineers gave at least some thought to bumpers on the new 6," says Adrian Lund, chief operating officer for the Institute. "In the front-into-flat-barrier test, only the relatively inexpensive grille and the foam inside the bumper had to be replaced."

In contrast, the G35 sustained more than four times as much damage in the same four bumper tests.

"The G35's bumpers are a disaster," says Lund. "Infiniti engineers attached an additional metal plate to the center of the rear bumper reinforcement bar to improve the car's performance in the pole test, but it didn't make much difference. There was extensive damage to body panels including a crushed trunk lid and floor pan."

Even in the rear-into-flat-barrier test, which isn't as demanding as the pole test, the G35 sustained more than $1,800 damage. In this test, the bumper cover split and both rear fenders buckled.

The Saab 9-3 was redesigned for 2003, but its bumpers didn't fare well in the Institute tests. One problem showed up in the front-into-angle-barrier test -- fixing the damage required removing the air conditioner condenser and the radiator just to replace the bumper bar. On average, the 9-3's bumpers allowed about $160 more damage per test than its 1999 predecessor.

One large luxury car: The Institute tested the new Mercedes E class, which was the second worst performer in this round of tests. Average damage per test was $1,300, and damage in the simplest front-into-flat-barrier test alone totaled almost $700.

"The front bumper on the E class is designed more for style than substance," Lund says. "In fact, the front bumper reinforcement bar is actually positioned rearward of the leading edges of the headlamps. This is a terrible design considering that headlamps are safety equipment that should be undamaged in such low-speed crashes."

There was almost $3,000 damage to the E class in the rear-into-pole test because the bumper failed to protect the car's expensive-to-fix fenders and trunk lid.

Two minivans: The Nissan Quest is an all-new design for 2004, "but Nissan engineers are going in the wrong direction in bumper design," Lund says. "The previous generation Quest did a good job resisting damage in a minor fender-bender. But buyers of the new model could get hit with big repair bills because its bumpers don't bump."

Damage to the new Quest was more than three times higher than the previous generation model. Repairs to the 2004 model topped $1,000 in three of the four tests.

"The Quest has a flimsy plastic reinforcement bar in the rear bumper that cracked in two in the flat-barrier test. Even in a minor bump at a fast walking speed, the rear body was crushed and the tailgate was dented," says Lund.

The Sienna fared somewhat better, but its highest damage total was in one of the flat-barrier tests, which should allow the least damage. In the rear-into-flat-barrier impact, the damage was $1,000 more for the new Sienna than for the 1998 model.

"The rear bumper should protect the expensive rear tailgate and other sheet metal from damage in such a simple crash," Lund says.


5 MPH CRASH TEST RESULTS
Front into flat barrier, Rear into flat barrier, Front into angle barrier,
Rear into pole, Total damage 4 tests, Average damage per test Bumper.
Ratings
Large luxury car:
2003 Mercedes E class $691 $586 $978 $2,944 $5,199 $1,300 POOR

Midsize moderately priced cars:
2003 Saab 9-3 $178 $529 $993 $1,313 $3,013 $753 MARGINAL
1999 Saab 9-3 $0 $156 $724 $1,482 $2,362 $591 ACCEPTABLE
2003 Infiniti G35 $679 $1,824 $1,431 $1,988 $5,922 $1,481 POOR

Midsize inexpensive car:
2003 Mazda6 $151 $521 $398 $297 $1,367 $342 ACCEPTABLE

Minivans:
2004 Toyota Sienna $380 $1,152 $987 $688 $3,207 $802 MARGINAL
1998 Toyota Sienna $513 $142 $771 $1,015 $2,441 $610 MARGINAL
2004 Nissan Quest $545 $1,599 $1,036 $1,367 $4,547 $1,137 POOR
1999 Nissan Quest $0 $378 $771 $316 $1,465 $366 GOOD

All repair costs reflect June 2003 parts and labor prices.
__________________
Stacy94PGT
My first car was a 67 Mustang Coupe, 2nd one was a 67 Cougar XR-7, 3rd one was a 66 Mustang Coupe. Why did I get rid of these cars for ? I know why, because I'm stupid, stupid, stupid.

My next Ford.....
Stacy94PGT is offline   Reply With Quote
Sponsored Links
Advertisement
 
Reply

  Ford Forums - Mustang Forum, Ford Trucks, Ford Focus and Ford Cars > Ford Cars and PAG Vehicles > Mazda Forum



Currently Active Users Viewing This Thread: 1 (0 members and 1 guests)
 
Thread Tools
Display Modes

Posting Rules
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is Off
Trackbacks are On
Pingbacks are On
Refbacks are On


Similar Threads
Thread Thread Starter Forum Replies Last Post
U.S.A.:MAZDA6 Sedan Awarded Top Scores in Recent Crash Tests Stacy94PGT Mazda Forum 0 09-22-2003 19:26
Local cars score well in crash tests Aussie Falcon The Pub 12 05-14-2003 01:11
Crash tests: small cars now safer Falchoon The Pub 7 06-27-2002 05:51
Toyota Leads Midsize Crash Test Rating RPO83 Ford Worldwide News 0 05-29-2002 09:37
Explorer Rules in Frontal Crash Tests LunaticSVT Ford Worldwide News 0 02-05-2002 00:20

Powered by vBadvanced CMPS v3.2.2

All times are GMT -7. The time now is 17:01.



Powered by vBulletin® Copyright ©2000 - 2014, Jelsoft Enterprises Ltd.
Content Relevant URLs by vBSEO 3.6.0
Garage Plus vBulletin Plugins by Drive Thru Online, Inc.