Ford Forums banner

Fuel injectors

2K views 13 replies 3 participants last post by  kennethbryant903 
#1 ·
I have an 07 mustang 4.6 I had a p0202 code and replaced the #2 injector. Then I had a p203 code so I replaced the rest of them. Now I have a p0202, p203, and a p303 code I would appreciate any advice
 
#4 ·
Could have gotten a faulty injector or 2.
One thing I do is I'll unplug whatever injector while it's running and note any difference in rpms.
Another thing is I'll swap out a known working injector like #1 with #2 and see if anything changes.
If it stays the same on codes and the way it runs, then the problem is with the connection either at the injector and/or the circuit supplying it.
If the code changes to show #1 is bad and #2 is good, then the problem is likely with the injector. You can do this with the #3 as well.
I'm leaning towards a poor connection somewhere, i.e. a bad ground. This is where a volt/ohm meter comes in.
The P303 will likely clear up once you get the the other codes taken care of.
 
#12 ·
It's also known as a poor mans noid light. You take a 194 bulb like the one below, commonly used in older cars in the instrument clusters and marker lights, straighten out the terminals so they can contact the inside of an injector plug. Like using a test light but a little easier.
Gesture Rectangle Font Auto part Art
 
#13 ·
Check all fuses in any way related to possible cause , especially the Powertrain Control Module and also all wiring / connections and any ground wires

Fuse Layout Ford Mustang 2005-2009


2007

Passenger compartment

Interior fuse box diagram: Ford Mustang (2007)


Assignment of the fuses in the Passenger compartment (2007)
Amp RatingDescription
1Mini relayAccessory delay #1
2Not used
310AWiper power/Blower motor relay
45APower mirrors
5Not used
65AAccessory delay feeds
710AElectrochromic mirror
810ACluster, Data Link Connector (DLC)
9Not used
105AIntrusion Sensing Module (ISM), Climate control
11Not used
125AClimate control, Ignition
13Not used
145AA/C cycle switch
1510ABrake On/Off (BOO) power
165ACluster
1710ARestraint Control Module (RCM), Passenger Occupant Detection System (PODS), Passenger Air bag Deactivation Indicator (PADI)
1810AAnti-lock Brake System (ABS)
195APowertrain Control Module (PCM) relay, Passive Anti-Theft System (PATS), Instrument cluster airbag warning lamp
2010ARadio (Start)
2110AStarter relay

Engine compartment
Under-hood fuse box diagram: Ford Mustang (2007)


Advertisements


Assignment of the fuses in the Power distribution box (2007)
Amp RatingDescription
1Not used
230A*Climate control blower
340A*Cooling fan
430A*Starter
530A*Driver front window motor
630A*Rear amplifier (Shaker 1000 radio)
730A*Passenger front window motor
840A*Anti-lock Brake System (ABS) #1
930A*Rear amplifier (Shaker 1000 radio)
1030A*Wipers
1130A*Driver rear window motor (Convertible only)
1230A*Passenger rear window motor (Convertible only)
1340A*Convertible top
1430A*Driver seat
1530A*Passenger seat
1630A*Front amplifier (Shaker 500 radio)
20Mini relayPCM
21Micro relayFuel pump
22Mini relayStarter
23Not used
24Micro relayA/C clutch
25Mini relayCooling fan (High-speed)
26Mini relayHorn
27Micro relayHigh beams
28Mini relayCooling fan (Low-speed)
29Mini relayRear defroster
30Micro relayFog lamps
31Mini relayConvertible top (Up)
32Mini relayClimate control blower
33Mini relayConvertible top (Down)
34Micro relayDecklid
3915A**Engine #4
4015A**Engine #2
4115 A**Fuel pump
4215 A**Engine #3
4310A**Alternator
4410A**Delayed accessory
4510A**PCM
4625A**Horn
4715 A**Engine #1
48DiodeA/C clutch
4915 A**A/C clutch
5015A**High beams
5110A**Convertible top
5230A**Rear defroster
53DiodePCM
54Not used
55Not used
5620A**Radio, SDARS
5720A**Decklid release
5815A**Fog lamps
5930A**SJB #5 (Passenger compartment fuse box)
60Not used
6120A**Power point #1 (Instrument panel)
6220A**SJB #7 (Passenger compartment fuse box)
6330A**SJB #6 (Passenger compartment fuse box)
6420A**Power point #2 (Console)
6530A**ABS #2
6625A**Heated seats
6730A**SJB #4 (Passenger compartment fuse box)
6820A**Ignition
* Cartridge Fuses
** Mini Fuses
 
This is an older thread, you may not receive a response, and could be reviving an old thread. Please consider creating a new thread.
Top